DEVICE BASED ON GAINASSB LEDS FOR MEASUREMENT OF WATER CONCENTRATION IN OIL
https://doi.org/10.21122/2220-9506-2017-8-2-142-150
Abstract
The main object of the work was developed the device based on GaInAsSb diodes for measurement water content in oil. Optical absorption method was used in this device. Three LEDs emitting in the range from 1.6 to 2.4 μm, and one wide-band GaSb/GaInAsSb/GaAlAsSb photodiode were used as sources of radiation and detectors.
The device was developed on the basis of selective optical absorption method of detection for measuring water content in oil. As sources of radiation, LEDs emitting in the range from 1.6 to 2.4 μm were used. The results of the experiments showed that the method used makes it possible to measure the water concentration in oil in the range from 0.2 to 40% with an relative error of not more than 2 %.
The technical requirements and operating parameters of the used light and photodiodes were established. Investigations of the dependence of the luminescence spectra of LEDs on temperature have shown the importance of using thermal control on the sources and detectors of radiation. The possibility of using one device for different types of oil, as well as oil products during preliminary calibration were shown in the paper. The importance of using a rotary pump for mixing and pumping the analyzed medium and a flow cell was established.
About the Authors
D. M. Kabanau
Optics, Optoelectronics & Laser Technology SSPA
Belarus
Belarus
Address for correspondence: Kabanau D.M. - SSPA «Optics, Optoelectronics & Laser Technology, Nezavisimosty Ave. 68, Minsk 220072, Belarus e-mail: d.kabanau@ifanbel.bas-net.by
Y. V. Lebiadok
Optics, Optoelectronics & Laser Technology SSPA
Belarus
Belarus
P. V. Shpak
B. I. Stepanov Institute of Physics of NAS of Belarus
Belarus
Belarus
S. M. Zhuk
Develop Group PHC
Belarus
Belarus
S. P. Stashkevich
Develop Group PHC
Belarus
Belarus
References
1. Kazin V.N., Urvantseva G.A. Fiziko-khimicheskie metody issledovaniya v ekologii i biologii [Physicochemical methods of research in ecology and biology]. Yaroslavl, Yaroslavl. State. University, 2002, 173 p.
2. Eliashevich M.A. Atomnaya i molekulyarnaya spektroskopiya [Atomic and molecular spectroscopy]. Moscow, Editorial URSS, 2001, 895 p.
3. Zolotov Yu.A. Dorokhova B.N., Fadeeva V.I.; ed. Zolotov Yu.A. Osnovy analiticheskoi khimii: Metody khimicheskogo analiza [Fundamentals of Analytical Chemistry: Methods of Chemical Analysis, book. 2]. Moscow, Higher School., 2002, 494 p.
4. Kalinina K.V., Molchanov S.S., Stoyanov N.D., Astakhova A.P., Salikhov H.M., Yakovlev Yu.P. Portable optical water-and-oil analyzer based on a mid-IR (1.6–2.4 μm) optron consisting of an LED array and a wideband photodiode.Technical Physics, 2010, vol. 55, is. 2, pр. 258–263.
5. Bogdanovich M.V., Kabanаu D.M., Lebiadok Y.V., Shpak P.V., Ryabtsev A.G., Ryabtsev G.I., Schemelev M.A., Andreev I.A., Kunitsina E.V., Ivanov E.V., Yakovlev Yu.P. Measurement of the water content in oil and oil products using IR light-emitting diode– photodiode optrons. Technical Physics, 2017, vol. 62, is. 2, рp. 344–346.
6. Stoyanov N.D., Zhurtanov B.Е., Astakhova A.P., Imenkov A.N., Yakovlev Yu.P. High-efficiency LEDs of 1.6–2.4 µm spectral range for medical diagnostics and environment monitoring. Semiconductors, 2003, vol. 37, is. 8, рp. 971–984.
7. Andreev I.A. Serebrennikova O.Yu., Sokolovsky G.S., Dyudeev V.V., Ilinskaya N.D., Konovalov G.G., Kunitsyna E.V., Yakovlev Yu.P. High-speed photodiodes for the mid-infrared spectral region 1.2–2.4 μm based on GaSb/GaInAsSb/GaAlAsSb heterostructures with a transmission band of 2–5 GHz. Semiconductors, 2013, vol. 47, is. 8, рp. 1103–1109.
8. Kunitsyna E.V., Grebenshchekova E.A., Konovalov G.G., Andreev I.A., Yakovlev Yu.P. Enhancement of the spectral sensitivity of photodiodes for the mid-IR spectral range. Semiconductors, 2016, vol. 50, is. 10, рp. 1403–1407.
9. Laurence S. Rothman. The HITRAN Database [Electronic resource] , Mode of access: http://www.hitran.org/ – Date of access: 12.03.2017.
10. Bezyazychnaya T.V., Bogdanovich M.V., Grigoriev A.V., Kabanov V.V., Kabanau D.M., Lebiadok Y.V., Lepchenkov K.V., Ryabtsev A.G., Ryabtsev G.I., Teplyashin L.L., Titovets V.S., Shpak P.V., Shchemlev M.A. Device for determining the water content of oil or petroleum products: patent RB 10477 U, IPC G01N21/35; Applicant Institute of Physics, National Academy of Sciences of Belarus. No. U20140233; Claimed. 14.06.2014; Publ. 30.12.14. Of. of the Bul., National center of intellectial property, 2014, no. 6, рр. 214.
11. Semenov A.N., Terentyev Y.V., Melzer B.Ya., Soloviev V.A., Popova Т.V., Nashchekin A.V., Andreev I.A., Kunitsyna E.V., Usikova A.A., Yakovlev Yu.P., Ivanov S.V. Molecular beam epitaxy of thermodynamically metastable GaInAsSb alloys for medium IR-range photodetectors. Semiconductors, 2010, vol. 44, is. 5, рp. 672–677.
Review
For citations:
Kabanau D.M., Lebiadok Y.V., Shpak P.V., Zhuk S.M., Stashkevich S.P. DEVICE BASED ON GAINASSB LEDS FOR MEASUREMENT OF WATER CONCENTRATION IN OIL. Devices and Methods of Measurements. 2017;8(2):142-150. (In Russ.) https://doi.org/10.21122/2220-9506-2017-8-2-142-150
Views:
2119
Email this article 